Representative model. Photo: IFCAR, Wikimedia Commons, Public domain

Recalls & complaints · NHTSA data

2004 Volkswagen Golf recalls

Every recall campaign and owner complaint NHTSA has on file for the 2004 model year. Not every vehicle is affected by every campaign: check a specific car by VIN below.

Recall campaigns: 6
Park-it warnings: 0
Complaints: 35
Latest campaign: Mar 7, 2014

Recall summary by component6

NHTSA Recalls API · cached ≤24 h

Component	Campaigns	Latest	Campaign IDs
Exterior lighting	3	May 11, 2009	09E025000 09E012000 07V063000
Engine and engine cooling	1	Mar 7, 2014	14E007000
Service brakes, hydraulic	1	Mar 29, 2007	07E023000
Fuel system, diesel	1	Dec 15, 2004	04V586000

Safety recalls6

NHTSA Recalls API · cached ≤24 h

0Park-it warnings

0Fixable over the air

Mar 7, 2014Latest campaign


Mar 7, 201414E007000	Engine and engine cooling: engine A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash. DetailsHide details for campaign 14E007000 What's wrong The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail. Risk A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash. Remedy Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911. Campaign NHTSA 14E007000 · Mar 7, 2014
May 11, 200909E025000	Exterior lighting: headlights DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH. DetailsHide details for campaign 09E025000 What's wrong DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS. Risk DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH. Remedy DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798. Campaign NHTSA 09E025000 · May 11, 2009
Apr 7, 200909E012000	Exterior lighting DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH. DetailsHide details for campaign 09E012000 What's wrong SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS. Risk DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH. Remedy SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589. Campaign NHTSA 09E012000 · Apr 7, 2009
Mar 29, 200707E023000	Service brakes, hydraulic: foundation components master cylinder LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH. DetailsHide details for campaign 07E023000 What's wrong CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID. Risk LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH. Remedy CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780. Campaign NHTSA 07E023000 · Mar 29, 2007
Feb 20, 200707V063000	Exterior lighting: brake lights switch THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. DetailsHide details for campaign 07V063000 What's wrong ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY. Risk THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING. Remedy DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987. Campaign NHTSA 07V063000 · Feb 20, 2007
Dec 15, 200404V586000	Fuel system, diesel FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE. DetailsHide details for campaign 04V586000 What's wrong ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP. Risk FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE. Remedy DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987. Campaign NHTSA 04V586000 · Dec 15, 2004

To see whether a recall is still open on your car, enter the VIN at nhtsa.gov/recalls or the Volkswagen recall lookup. Recall repairs are free at a franchised dealer (federal law; see limits).

Buying a used 2004 Volkswagen Golf? Recalls cover the model; a history report checks one car's title, odometer and accident records. VinAudit history report → Sponsored · disclosure

Owner complaints by component35

NHTSA Complaints API · cached ≤24 h

35Complaints filed

3Involving a crash

1Involving a fire

0Injuries reported · 1 death

Component	Complaints	%	Crashes	Fires
Air bags	7	20	1	0
Electrical system	6	17	0	1
Fuel/propulsion system	4	11	0	0
Fuel system	4	11	0	0
Power train	4	11	0	0
Engine and engine cooling	4	11	0	0
Latches/locks/linkages	3	9	0	0
Unknown or other	2	6	0	0
Diesel	2	6	0	0
Exterior lighting	2	6	0	0
Vehicle speed control	2	6	1	0
Gasoline	1	3	0	0
Structure	1	3	0	0
Other	1	3	0	0
Visibility	1	3	0	0

5 more components with fewer complaints not shown. An owner can tag several components, so percentages add up to more than 100. Complaints are unverified owner reports, de-duplicated by NHTSA ODI number, merged from NHTSA model names Golf, Golf/GTI.

Latest reports

Fuel/propulsion system
“Car will shut off while driving around town or cruising on the highway (very dangerous) once fuel tank drops to 1/4 tank. I believe it to be faulty fuel pump design.”
Filed 09/14/2019 · ODI 11255490
Fuel/propulsion system
“I started smelling fuel inside my car, and I replaced the gas cap. The smell kept getting stronger and it gave me headaches while driving.”
Filed 07/27/2018 · ODI 11114213
Fuel/propulsion system
“Tl* the contact owns a 2004 volkswagen gti. While driving approximately 60 mph, the vehicle lost power. After a couple of seconds, the vehicle would regain power.”
Filed 08/09/2017 · ODI 11013920

Other Volkswagen Golf model years

All years: 2024 · 2023 · 2022 · 2021 · 2020 · 2019 · 2018 · 2017 · 2016 · 2015 · 2014 · 2013 · 2012 · 2011 · 2010 · 2006 · 2005 · 2004 · 2003 · 2002 · 2001 · 2000

Other Volkswagen models

All Volkswagen models and years →

2004 Volkswagen Golf recall questions

How many recalls does the 2004 Volkswagen Golf have?

NHTSA lists 6 safety recall campaigns for the 2004 Volkswagen Golf. The most recent, 14E007000 (reported March 7, 2014), concerns engine and engine cooling. Not every vehicle is covered by every campaign; check a specific car by VIN.

What are the 2004 Volkswagen Golf recalls for?

The largest group is exterior lighting, with 3 campaigns. Others: engine and engine cooling (1), service brakes, hydraulic (1), fuel system, diesel (1). Each campaign below lists the defect, the risk and the free remedy.

What is the most common complaint about the 2004 Volkswagen Golf?

Air bags is the most-reported component, named in 7 complaints out of 35 filed with NHTSA (20%). Across all complaints, owners reported 3 crashs and 1 fire. Complaints are unverified owner reports.

How do I check if a recall is open on my 2004 Volkswagen Golf?

Enter the 17-character VIN at nhtsa.gov/recalls or the Volkswagen recall lookup. That shows campaigns still unrepaired on that exact car. Safety recall repairs are free at a franchised Volkswagen dealer.

Check a specific Volkswagen by VIN

Free · No signup · US-market vehicles, 1981+

Need the factory options too? See the Volkswagen build sheet & window sticker guide.

Recall summary by component6

Safety recalls6

Engine and engine cooling: engine

Exterior lighting: headlights

Exterior lighting

Service brakes, hydraulic: foundation components master cylinder

Exterior lighting: brake lights switch

Fuel system, diesel